Hull/ship construction
• Main engine exhaust from engine room to transom with hull plating reinforced (2023)
• Upgraded to 5086 Aluminum piping (2023)
• Below water seawater piping for chain locker in Bow replaced hull plating reinforced (2022)
• Anchor and anchor chains cleaned and re galvanized (2023)
• Complete paint job on vessel (Rybovich 2023)
• New bottom paint and prop speed on all running gear (2024)
Electrical
• New Atlas switchboard installed (2022)
• All high-voltage wires for air-conditioning brought up to current specifications
• Shore power units overhauled automation made two new switchboard and tested (2023)
• Engine room, overhead lighting overhaul for LED conversion
• New frequency drive for compressor air-conditioning replaced
Hydraulic - 2023
• Top deck crane complete overhaul and new controllers
• Forward bow crane complete overhaul and new controller
• Windless overhaul
• Gearbox for winless rebuild
• All hydraulic hoses that showed wear replaced
Propulsion - 2022
• Port and starboard main engine complete top end rebuild with all CAT OEM parts
• New turbos, injectors, aftercoolers and valve guides
• New resilient mounting for main engines and gearbox
• Install CAT cylinder heads and injectors
• Install new lifter spring guides, thermostats, spacer
• Plates, expansion tank cap, injector wiring harnesses
• Injector hold down bolts, fuel filters and exhaust
• Manifold hardware (bolts / nuts)
• Remove, chemically clean, pressure check and install aftercooler core
• Inspect camshafts
• Clean / inspect engine speed and timing sensors
• Crankshaft vibration damper
• Check / install current software in Ecm's.
• Install all removals with new seals and gaskets
• Remove, clean, pressure test and install heat exchanger (plate seal replacement included)
• Install new CAT fuel priming pump and raw water pump
• Install CAT Reman fuel transfer pump and jacket water pump
• Port and starboard main engine exhaust overhaul with new exhaust lagging and all new associated hardware (2022)
• Port and starboard gearbox complete overhaul - installed rear main seals in both engines while gearboxes getting rebuilt (2022)
• Complete engine room refit and repaint with awl grip paint
• Updated engine lighting to LED
Generators - 2022
• Two new CAT 99kW generators installed
• Includes platinum warranty expiring 9/9/27, can be extended further with Caterpillar
• Wires for generators updated and new batteries installed
• Complete generator exhaust overhaul and new mufflers with updated stainless steel generator enclosure
Interior
• New vinyl installed (bridge deck salon, engine control room and crew galley)
• New carpet and padding installed throughout the entire boat (2023)
• Pullman bed added in twin guest cabin (2023)
• Bridge console updated
• Crew quarters updated
Plumbing - 2024
• Fresh, grey and black water tanks cleaned and sterilized
• New coating and sealer applied by Rybovich to tanks
• Sea water piping replaced and overhauled
Air-conditioning
• Air conditioning plant overhaul
• All ductwork professionally cleaned
Sewage treatment
• Updated transfer system installed
Freshwater system
• Water makers, overhaul, new pumps, installed hoses, etc
Stabilizer - 2022
• Stabilizer system overhaul, new seals, etc
Exterior additions
• New raised hot tub and lounge area (2023)
• New custom Frameless windscreen and stations around flybridge (2023)
• New exterior deck lights (2022)
• New overhead ceiling track mounting system for for all decks (2023)
• Paint job
• Deck head mounting overhaul (2023)
• Updated EAS track replacement around entire vessel with new load rating
• New teak deck on swim platform
• New sunshade over flybridge hot tub area
• New exterior cushions
AVIT
• Complete AVIT overhaul including stereos, controllers, iPads (2024)
Fuel systems
• Tender diesel fueling station installed
Ship’s computers
• New computers for Captain, mate, engineer
Navigation
• Display update (2022)
HVAC
• New compressors installed in main refrigerators and freezers
Appliances
• Washer and dryer for control room
• New ice machine in galley
• New cooktop in galley (2023)
• New commercial ice maker in control room installed
Compressed air system
• New air dryer (2022)
Toys
• Two new Yamaha jet skis (2022)
• New inflatable island system (2024)
• inflatable tender completely overhauled (2022)